| 温 健,潘师翰,郑鑫,等.产纤溶酶海洋枯草芽孢菌的液体发酵条件优化[J].中国海洋药物,2015,34(3):35-45. |
| 产纤溶酶海洋枯草芽孢菌的液体发酵条件优化 |
| Optimization of liquid fermentationconditions of marine Bacillus subtils for producing the fibrinolytic enzyme |
| 投稿时间：2014-09-22 修订日期：2014-11-18 |
| DOI： |
| 中文关键词: 枯草芽孢杆菌 纤溶酶 液体发酵 plackett-Burman(PB)设计 响应面法 |
| English Keywords:Bacillus subtilis fibrinolytic enzyme Liquid-state fermentation Plakett-Burman (PB) design response surface methodology |
| Fund Project: |
|
| 摘要点击次数: 5836 |
| 全文下载次数: 1501 |
| 中文摘要: |
| 为进一步增加高产纤溶酶海洋菌株Y-6-A的产酶量,采用响应面法对其液体发酵条件进行优化。先采用单因素实验考查各因素对菌株产酶的影响,并在此基础上利用Plackett-Burman设计筛选到影响菌株产酶的四个主要因素分别为：可溶性淀粉、黄豆粕粉、温度和转速,接着通过最陡爬坡实验逼近酶活最高区域,最后根据Box-Behnken中心组合实验设计对各显著因子进行优化。最终得到最佳发酵条件为：可溶性淀粉4.61g/100mL,黄豆粕粉2.33g/100mL,温度31.2℃,转速184r/min,在此发酵条件下得到的酶活为3606.23IU/mL,经三次验证实验测得的酶活稳定在3580.32±14.82IU/mL,较优化前提高了22.4%,此外,实验值与预测值之间的相对误差为0.63%。表明该优化结果比较理想。 |
| English Summary: |
| To enhance the enzyme production of high- yield marine stain Y-6-A futher,Response surface analysis was applied to optimize the liquid fermentation conditions ,Fristly, the impact of single factors on fibrinolytic enzyme production was studied and through the Plakett-Burman design, the most significant effect on fibrinolytic enzyme production was obstained which include soluble starch , soybean meal, temperature and speed, then, the highest fibrinolytic activity area was investigated by steepest climbing experiments , finally, different levels of the most four significant factors were oprtimized through central composite designs by Box-Behnken. As aresult , the optimal fermentation conditions of strain Y-6-A was determined for 4.61% soluble starch 2.33% soybean meal, temperature at 31.2℃, rotate at 184 r/min, under the optimal conditions, the enzyme activity was 3606.06IU/mL, three times validation experiments showed that the activity of fibrinolytic enzyme was stable at 3580±14.82IU/mL , the optimized enzyme activity was 22.4% higher than before .In addition, relative error betwen the actual value and predictive value was 0.7%, therefore,the optimization results was resonable. |
| 查看全文 查看/发表评论 下载PDF阅读器 |
|
| 关闭 |
|
|
|